.jpg)
Clean
Water and No Stink
|
Meet
the requirements of water recycling with the only filtration/recycling
system that insures 100% non-interference with car wash
operation.
Check
out the Water Analysis link below for actual water
test results taken by the customer's sewer department.
You don't get water test results more reliable than from
the sewer department themselves. It shows test results
before the Extreme Clean System was installed and then
after five months in operation using the original filter
media. This is the toughest case scenario. A full service
truck wash using high caustic soaps and aluminum brighteners
in their washing process and recycling their wastewater.
"The Wash Rack" has (13) pressure washers running at 5
gpm each. They use recycled water for all washing operations
and primary rinse steps, their RO final rinse system adds
a small amount of water to the system causing it to overflow
to the sanitary sewer.
Extreme Clean Specifications Truck Wash Water Analysis
Why
Buy Extreme Clean?
What
makes the Extreme Clean Different?
The
competition: Most reclaim systems require multiple
large in-ground pits that are costly to install. These
installation costs generally make even the least expensive
system more costly once installed than the Extreme Clean.
The Extreme Clean: Only requires a collection pit
to pump wastewater to the reclaim system.
The competition: Retrofitting existing car washes
is very expensive, floors and drainage systems require
major changes, extensive plumbing must be added. Then
include interruption of washing for days and even weeks.
The Extreme Clean: The existing collection and
drainage system is utilized, only a wastewater pickup
point is required. Pumps are installed in the collection
system in only hours. Most often without discontinuing
washing operations.
The competition: These large under ground pits
provide the settling time for solids to settle out and
then require frequent maintenance to clean out the accumulated
solids.
The Extreme Clean: Above ground (cone bottom) tanks
are an integral part of the Extreme Clean system. Solids
that settle out in its tanks and can be easily purged
and removed from the system.
The competition: Oils and sludge are accumulated
in these underground pits (sumps) require sludge to be
pumped from them. In most cases this waste must be hauled
away as hazardous material.
The Extreme Clean: Extensive oil coalescing and
active skimming is standard on the Extreme Clean, 95%
water free oil is removed from the system and deposited
into a waste oil container for disposal and/or subsequent
sale for recycling. Hydro-Biodigesters bacterial product
(HBD) live within the sludge consuming hydrocarbons- grease
and oils.
The competition: Most systems on the market will
interrupt washing operations when they breakdown or require
maintenance. This requires the operator to bypass the
reclaim system to maintain washing and continue to make
money. This also requires that the operator be notified
that the system is down so bypassing can be accomplished.
The Extreme Clean: The Extreme Clean cannot interrupt
washing operations. The system can even be turned off
and wastewater will still pass through uninterrupted.
Extreme Clean owners don't loose money due to loss of
operation and turned away customers.
The competition: Most systems use cartridge or
bag filters that require taking the system off line for
costly replacement or cleaning of these filters.
The Extreme Clean: Only continuous media filters
(CMAFU) and backflushable media filters are used. All
are automatic and require little user attention. The Extreme
Clean system backflushes automatically, on demand in just
minutes and each night (as programmed). No down time here!
The competition: Rainbows on the finished vehicle
from oils don't make happy customers.
The Extreme Clean: Hydrocarbons (oils) are completely
removed with the Extreme Clean.
The competition: Most reclaim systems stink! Foul
smelling cars don't bring customers back. Ozone and other
corrosives are used to kill naturally occurring bacteria
and are almost never 100% successful. These do damage
to customer's vehicles and car-washing equipment and are
very costly to use.
The Extreme Clean: "We Won't Put a Skunk In Your
Trunk" The Extreme Clean system uses Hydro-Biodigesters
to eliminate odor. Targeted bacteria, enzymes, micro and
macronutrients work together to out compete natural bacteria
providing a smell free system. See Biodigesters.
The competition: Experience is lacking in the reclaim
business.
The Extreme Clean: Is manufactured by Hydro Engineering
Inc. We have over 1500 wastewater treatment systems in
daily operation. With three GSA (Government) contracts
covering our equipment and 19 years of experience in the
business we know how to make it work.
Back
to Waste Water Treatment
